Review Hotchkis F/R sways on my X
#1
Hotchkis F/R sways on my X
The difference. My goodness... I can now turn like a hungry predator chasing its prey. On all seasons too, mind you! There is a corner I've dubbed Dead Man's Curve because there are frequently news stories about deaths there, and you always see car parts scattered throughout. Normally I take it at a pretty reserved speed, being public roads and all. Fortunately I was coming home late recently and the roads were empty, so long story short I was able to take the turn much faster without the traditional scary-*** floating feeling accompanied with body roll. That same planted feeling translates to every corner for all the beans I've given the car thus far.
Admittedly, I should have gone for the lesser of the two stiffness settings up front. The bumps are a bit too pronounced now for my daily commute. The thought was I would get more oversteer because sideways racecar. Some day I'll set it looser but it's still cold af here. The install was a bear because of this, space heater or no. I think setting the rear on the middle setting was the correct choice however.
This whole install justified me buying a grease gun because of those wonderful zerk fittings, an air ratchet for the front skid plate's bajillion bolts, and a creeper to roll around on, so it's a win even before installation. All the stuff!
I did have some install problems on the front sway. The left nut got chewed up and I essentially destroyed the nut and sway bracket trying to get it off. Dremels are ****ing boss though. Fortunately I found an OEM replacement sway bracket for $20 shipped and bought a series of washers and big ol' anodized nuts from the auto parts store so everything is now situated just fine. Of course I threw on some loctite for extra insurance.
The rear install was a bit difficult too. Since I have the X, I actually had to drop my exhaust at the mufflers, remove the center brace, and brace it at the center-ish point with my floor jack several inches lower to be able to navigate the old sway out. I snapped off one of the two middle exhaust hanger studs, so I'll probably bring that to a shop to get drilled and replaced. Fortunately I haven't noticed any drone and it passed my jiggle test so I'm calling it good for now.
Overall the install was fun and completely revitalized the way my car handles. I know there are others on this site, but I'll upload a pic of my old rear sway bar vs the new one. It looks like a toothpick comparatively.
EDIT: Uploaded pic of old vs new rear sway
Admittedly, I should have gone for the lesser of the two stiffness settings up front. The bumps are a bit too pronounced now for my daily commute. The thought was I would get more oversteer because sideways racecar. Some day I'll set it looser but it's still cold af here. The install was a bear because of this, space heater or no. I think setting the rear on the middle setting was the correct choice however.
This whole install justified me buying a grease gun because of those wonderful zerk fittings, an air ratchet for the front skid plate's bajillion bolts, and a creeper to roll around on, so it's a win even before installation. All the stuff!
I did have some install problems on the front sway. The left nut got chewed up and I essentially destroyed the nut and sway bracket trying to get it off. Dremels are ****ing boss though. Fortunately I found an OEM replacement sway bracket for $20 shipped and bought a series of washers and big ol' anodized nuts from the auto parts store so everything is now situated just fine. Of course I threw on some loctite for extra insurance.
The rear install was a bit difficult too. Since I have the X, I actually had to drop my exhaust at the mufflers, remove the center brace, and brace it at the center-ish point with my floor jack several inches lower to be able to navigate the old sway out. I snapped off one of the two middle exhaust hanger studs, so I'll probably bring that to a shop to get drilled and replaced. Fortunately I haven't noticed any drone and it passed my jiggle test so I'm calling it good for now.
Overall the install was fun and completely revitalized the way my car handles. I know there are others on this site, but I'll upload a pic of my old rear sway bar vs the new one. It looks like a toothpick comparatively.
EDIT: Uploaded pic of old vs new rear sway
Last edited by user 373907820; 03-10-2018 at 11:11 AM.
#5
#7
Trending Topics
Thread
Thread Starter
Forum
Replies
Last Post
MaxToTheG37
Brakes, Suspension, Wheels & Tires
4
12-04-2008 01:44 AM