Bad MAF vs. Vacuum Leak
#31
You have tried 3 different fuel pumps and still have low fuel pressure under load. I don't think it is the pump.
I assume you are using the factory wires, so they should be ok.
It is not your tune. The stock fuel system can provide enough fuel flow for the typical intake/exhaust bolt-ons.
(based on my calculations, the stock fuel system can support up to ~330 wheel HP)
If this was my car I would measure the voltage and current at the fuel pump while under load.
This does require special tools, but I think the next step is to verify the electrical side.
I assume you are using the factory wires, so they should be ok.
It is not your tune. The stock fuel system can provide enough fuel flow for the typical intake/exhaust bolt-ons.
(based on my calculations, the stock fuel system can support up to ~330 wheel HP)
If this was my car I would measure the voltage and current at the fuel pump while under load.
This does require special tools, but I think the next step is to verify the electrical side.
If so, anyone know the pinout of the harness?
#33
Moderador
I don't want to mess you up even more but FYI
This was from a Titian
This was from a Titian
The following users liked this post:
ILM-NC G37S (08-10-2020)
#35
Moderador
Similar problem, low pressure under load.
#36
Moderador
This same gunk will lower the pressure overall. It might be fine on light or part throttle since it is able to keep rails full just not at WOT.
It's worth checking it out.
The dilema here is that for those that know and need a way to fix this is. New housing or adding your own filter down the line.
As some here will dwell with E85 this will mean shorter intervals in the fuel department
I'm not saying this is your problem but if voltage checked out and you're meeting pressures at half of the time you have a restriction or possible leak between pump and housing
#37
#38
Moderador
We hooked a manual FP gauge and it would drop to 30-40s erratically.
I took the assembly home and re used the pump in another project, this was what the filter looked like.
Thread
Thread Starter
Forum
Replies
Last Post
dom_sinserious
Engine, Drivetrain & Forced-Induction
23
09-26-2022 09:13 AM
coastalsquirrel
Newbie Corner
10
12-13-2014 08:09 PM
PR_G37
TSB - Technical Bulletins
11
08-23-2011 04:22 PM
sobi6111
Private Classifieds
7
10-22-2010 03:52 PM